Again, unless the materials or garments after washing, have been dried before immersion in the fireproofing solution, this solution can not be kept uniform since, each garment being wet when put in leaves the solution weaker than before and therefore of less protective value. To dry each garment between the washing and the fireproofing entails so much trouble and labor and expense that it would obviously prevent any general adoption of the practise. Although the substances I have mentioned and the salts of ammonium in particular, possess in a high degree the property of rendering material fireproof, there is one substance which confers the property of resisting fire to cotton goods in such a remarkable degree that it has long attracted attention and must be specially mentioned, and that is sodium tungstate.
A piece of muslin soaked in a weak solution of sodium tungstate and then dried is practically non-inflammable but unfortunately this salt is again so excessively soluble in water that a mere rinsing in clean water is sufficient to remove it completely and the fireproofing is lost. And this applies not only to sodium tungstate but also to all the other salts which have, from time to time, been recommended for fireproofing purposes; the result is not permanent because the proofing is at once removed when the goods are washed in the ordinary way.
The problem on which I was engaged for several years and which has now been successfully solved, in a very simple manner, was that of attempting to discover some process which not only made the goods non-inflammable but also permanently non-inflammable, and the researches on this subject were originally started in connection with flannelette, a material very largely and widely used for clothing, especially by the poorer classes, and one of the most, if not the most, inflammable of all cotton goods.
Flannelette may be briefly described as a kind of calico the surface of one or both sides of which has been "carded" or "raised" into a nap, the result being that the surface of the calico becomes covered with a fluff of minute fibers somewhat resembling a thin layer of cotton wool. This effect is produced by subjecting the surface of the calico to the action of a series of revolving rollers covered with a vast number of small pieces of sharp steel wire, which tear up the surface, and the material is passed over these rollers over and over again until the required amount of nap has been raised. The result of this superficial covering of nap is—as everybody who has handled flannelette will know—a warm, pleasant and cosy feel and this is no doubt due to a covering of air being imprisoned by the minute fibers thus producing a layer which acts as a non-conductor much in the same way as in the case of flannel.
In the first two samples in the little book which you each received as you entered the hall are calico and flannelette and you will notice at
